Web Encyclopedia News Blogs Forums

Project Mercury

Project Mercury was the first human spaceflight program of the United States. It ran from 1959 through 1963 with the goal of putting a man in orbit around the Earth. The Mercury-Atlas 6 flight on February 20, 1962 was the first Mercury flight to achieve this goal.
Early planning and research was carried out by the National Advisory Committee for Aeronautics, and the program was officially conducted by the newly created NASA. The name comes from Mercury, a Roman mythological god who is often seen as a symbol of speed. Mercury is also the name of the innermost planet of the solar system, which moves faster than any other and hence provides an image of speed, although Project Mercury had no other connection to that planet.

The Mercury program cost around $384 million, or about $2.7 billion in 2007 dollars.

Spacecraft

Because of their small size it was said that the Mercury spacecraft capsules were not ridden, but worn. With 1.7 cubic meters of habitable volume, the capsule was just large enough for the single crew member. Inside were 120 controls: 55 electrical switches, 30 fuses and 35 mechanical levers. The spacecraft was designed by Max Faget and NASA's Space Task Group.

During the launch phase of the mission, the Mercury spacecraft and astronaut were protected from launch vehicle failures by the Launch Escape System. The LES consisted of a solid fuel, 52,000 lbf (231 kN) thrust rocket mounted on a tower above the spacecraft. In the event of a launch abort, the LES would fire for 1 second, pulling the Mercury spacecraft and the astronaut away from a defective launch vehicle. The spacecraft would then descend on its parachute recovery system. After booster engine cutoff (BECO), the LES was no longer needed and was separated from the spacecraft by a solid fuel, 800 lbf (3.6 kN) thrust jettison rocket that fired for 1.5 seconds. Unfortunately, as with the later Apollo and Gemini programs, the scientists believed that if there was a catastrophic failure with the launch vehicle, then the possibilities of survival were minimal even with the tower in place. There simply wasn't enough time between the detection of the problem and the resulting consequences. There was never a problem during launch that caused the firing of the tower, and in Project Gemini, Gemini 6 misfired but was aborted before any trouble arose.

To separate the Mercury spacecraft from the launch vehicle, the spacecraft fired three small solid-fuel, 400 lbf (1.8 kN) thrust rockets for 1 second. These rockets are called the Posigrade rockets.

The spacecraft was only equipped with attitude control thrusters - after orbit insertion and before retrofire they could not change their orbit. There were three sets of high and low powered automatic control jets and separate manual jets - one for each axis (yaw, pitch, and roll), supplied from two separate fuel tanks - one automatic and one manual. The pilot could use any one of the three thruster systems and fuel them from either of the two fuel tanks to provide spacecraft attitude control.

The Mercury spacecraft were designed to be totally controllable from the ground in the event that something impaired the pilot's ability to function.

The spacecraft had three solid-fuel, 1000 lbf (4.5 kN) thrust retrorockets that fired for 10 seconds each. One was sufficient to return the spacecraft to earth if the other two failed. The firing sequence (known as ripple firing) required firing the first retro, followed by the second retro five seconds later (while the first was still firing). Five seconds after that, the third retro fired (while the second retro was still firing).

There was a small metal flap at the nose of the spacecraft called the "spoiler". If the spacecraft started to reenter nose first (another stable reentry attitude for the capsule), airflow over the "spoiler" would flip the spacecraft around to the proper, heatshield-first reentry attitude, a technique called 'Shuttlecocking'. During reentry, the astronaut would experience about 4 g-forces.

Initial designs for the spacecraft suggested the use of either beryllium heat-sink heat shields or an ablative shield. Extensive testing settled the issue - ablative shields proved to be reliable (so much so that the initial shield thickness was safely reduced, allowing a lower total spacecraft weight), easier to produce (at that time, beryllium was only produced in sufficient quantities by a single company in the US) and cheaper.

NASA ordered 20 production spacecraft, numbered 1 through 20, from McDonnell Aircraft Company, St. Louis, Missouri. Five of the twenty spacecraft, #10, 12, 15, 17, and 19, were not flown. Spacecraft #3 and #4 were destroyed during unmanned test flights. Spacecraft #11 sank and was recovered from the bottom of the Atlantic Ocean after 38 years. Some spacecraft were modified after initial production (refurbished after launch abort, modified for longer missions, etc) and received a letter designation after their number, examples 2B, 15B. Some spacecraft were modified twice; for example, spacecraft 15 became 15A and then 15B.

A number of Mercury Boilerplate spacecraft (including mockup/prototype/replica spacecrafts, made from non-flight materials or lacking production spacecraft systems and/or hardware) were also made by NASA and McDonnell Aircraft. They were designed and used to test spacecraft recovery systems, and escape tower and rocket motors. Formal tests were done on test pad at Langley and at Wallops Island using the Little Joe and Big Joe Atlas rockets.NASA Mercury History Sections #44 and #47

Boosters

The Mercury program used three boosters:

Little Joe - 8 suborbital robotic flights, 2 carrying monkeys. Launch escape system tests.

Redstone - 4 suborbital robotic flights, 1 carrying a chimpanzee; 2 piloted suborbital flights.

Atlas - 4 suborbital robotic flights; 2 orbital robotic flights, 1 carrying a chimpanzee; 4 piloted orbital flights.

Little Joe and a Mercury Boilerplate A Fieldguide to American Spacecraft was used to test the escape tower and abort procedures.Mercury Boilerplate Tests Redstone was used for suborbital flights, and Atlas for orbital ones. Starting in October, 1958, Jupiter missiles were also considered as suborbital launch vehicles for the Mercury program, but were cut from the program in July, 1959 due to budget constraints. The Atlas boosters required extra strengthening in order to handle the increased weight of the Mercury capsules beyond that of the nuclear warheads they were designed to carry. Little Joe was a solid-propellant booster designed specially for the Mercury program.
The Titan missile was also considered for use for later Mercury missions; however, the Mercury program was terminated before these missions were flown. The Titan was used for the Gemini program which followed Mercury.

The Mercury program used a Scout booster for a single flight, Mercury-Scout 1, which launched a small satellite intended to evaluate the worldwide Mercury Tracking Network. The rocket was destroyed by the Range Safety Officer after 44 seconds of flight.

Unmanned flights

The program included 20 robotic launches. Not all of these were intended to reach space and not all were successful in completing their objectives. Four of these flights included non-human primates, starting with the fifth flight (1959) which launched a Rhesus macaque named Sam (after the Air Force's School of Aviation Medicine). The Mercury program's complete roster of non-human space-farers is given below:

Sam, a Rhesus macaque, launched December 4, 1959 on Little Joe 2 to 85 km altitude.

Miss Sam, a Rhesus macaque, launched January 21, 1960 on Little Joe 1B to 15 km altitude.

Ham, a chimpanzee, launched January 31, 1961 on Mercury-Redstone 2 for a suborbital flight.

Enos, a chimpanzee, launched November 29, 1961 on Mercury-Atlas 5 for a 2-orbit flight.

Astronauts

The first Americans to venture into space were drawn from a group of 110 military pilots chosen for their flight test experience and because they met certain physical requirements. Seven of those 110 became astronauts in April 1959. Six of the seven flew Mercury missions (Deke Slayton was removed from flight status due to a heart condition). Beginning with Alan Shepard's Freedom 7 flight, the astronauts named their own spacecraft, and all added "7" to the name to acknowledge the teamwork of their fellow astronauts.

Mercury had seven prime astronauts, all former military test pilots, known as the Mercury Seven. NASA announced the selection of these astronauts on April 9, 1959.

Malcolm Scott Carpenter, USN (1925-)

Leroy Gordon "Gordo" Cooper, Jr., USAF (1927-2004)

John Herschel Glenn, Jr., USMC (1921-) First American to orbit the earth.

Virgil Ivan "Gus" Grissom, USAF (1926-1967)

Walter Marty "Wally" Schirra, Jr., USN (1923-2007)

Alan Bartlett Shepard, Jr., USN (1923-1998) First American in space.

Donald Kent "Deke" Slayton, USAF (1924-1993) Grounded in 1962 due to irregular heartbeat, reinstated in 1972 and later flew on the Apollo-Soyuz Test Project in 1975.

Mercury Flight insignias

Flight patches that purport to be patches from various Mercury missions are available to the public. In reality, these patches were designed by private entrepreneurs long after the Mercury program ended. When genuine flight patches were created by crews in the Gemini program, this caused a public demand for Mercury flight patches, which was filled by these private entrepreneurs. The only patches the Mercury astronauts wore were the NASA logo and a name tag. Each manned Mercury spacecraft, however, was decorated with a flight insignia. These are the genuine Mercury flight insignias.

Miscellaneous

The Mercury astronauts trained, in part, at NASA Langley Research Center in Hampton, Virginia, under Flight Surgeon William K. Douglas and Keith G. Lindell (COL, USAF). Several bridges throughout the city bear the name of the Mercury astronauts, and U.S. Route 258, a major north-south route in the cities of Hampton and Newport News is named Mercury Boulevard, honoring the Mercury program.

The names of five of the Mercury astronauts are also commemorated in the popular 1960s TV show Thunderbirds. In the series, Jeff Tracy, the founder of the fictional International Rescue organization, is a millionaire ex-astronaut who has named his five sons -- Scott, Virgil, Alan, John and Gordon -- after the real-life Mercury astronauts.

The Randall Model 17 Knife "Astro" was designed for the Mercury astronauts. The final design was done by Gordon Cooper. These knives were never supplied by NASA to the Mercury astronauts, but rather were purchased out of their own pocket. Two of the seven original "Astros" are on display in the Smithsonian. Gus Grissom's was recovered when the Liberty Bell 7 was recovered from the Atlantic Ocean and it only needed cleaning. The Astro is still in production unchanged.

External links

The Mercury Project (Kennedy Space Center)

Project Mercury A Chronology (Prepared by James M. Grimwood)

Space Medicine In Project Mercury By Mae Mills Link

Project Mercury Drawings and Technical Diagrams

Technical Diagrams and Drawings

Mercury-Atlas Diagrams

Project Mercury Simulator for the PC (Orbiter)

Project Mercury Simulator for Mac and PC

The Mercury Redstone Project (PDF) December 1964

Project Mercury familiarization manual (PDF) November 1961

Various PDFs of historical Mercury documents including familiarization manuals.

Buzz Aldrin's Race Into Space: a game that simulates the Space Race

Mercury Little Joe DVD

Randall Model 17 "Astro" designed for Project Mercury

NASA History Series Publications (many of which are on-line)

U.S. Spaceflight History- Mercury Program

References

This section is sponsored by:
project mercury
Fastest and Relevant project mercury results
FastestINFO.com

Laptops
Find a great deal on a Laptop Computer by browsing our Laptop Computer listings.
www.LaptopComputersInfo.com

Complete Computer Types & Its Part
Find Computer Type& Parts that you Need. Easy Deal at Low Price!
1st-in-Computers.com

Laptops
Laptops Info
www.givemearticles.com

laptops
Don't just search for laptops, find results.
www.ask.com

laptops
Search for laptops here.
www.aywoh.com

Laptops
Find articles, advice and resources on laptops.
www.experttopics.com